单个RP-3航空煤油液滴的超临界蒸发实验研究

推进技术 ›› 2016, Vol. 37 ›› Issue (8): 1422-1430.

单个RP-3航空煤油液滴的超临界蒸发实验研究

周舟,范玮,靳乐,张晋,申帅

西北工业大学动力与能源学院，陕西西安 710072,西北工业大学动力与能源学院，陕西西安 710072,西北工业大学动力与能源学院，陕西西安 710072,西北工业大学动力与能源学院，陕西西安 710072,西北工业大学动力与能源学院，陕西西安 710072

发布日期:2021-08-15
作者简介:周舟，男，硕士生，研究领域为发动机燃烧与流动。
基金资助:
国家自然科学基金(91441201；51176158；51376151)；教育部博士点基金(20126102110029)。

Experimental Investigation on Supercritical Evaporation of

School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China,School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China,School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China,School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China and School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China

Published:2021-08-15

摘要/Abstract

摘要： 目前以航空发动机为背景的针对液态碳氢燃料的超临界蒸发研究很少，鉴于未来高性能航空发动机的研制需求，选取国产RP-3航空煤油为研究对象，对液滴的超临界蒸发进行了研究。分析了蒸发过程中不同环境参数下液滴无量纲直径的平方随时间的变化规律，实验结果表明超临界蒸发与常规亚临界蒸发特性存在很大的差异；根据实验结果绘制了液滴蒸发时间随环境参数变化的曲线图，并分析了蒸发过程中不稳定度的变化规律，发现在不同的温度范围内环境压力对液滴蒸发时间的影响规律是截然不同的，同时不稳定度Bi随环境温度及压力的升高而增大；对不同工况下液滴的瞬态蒸发常数以及平均蒸发常数进行了定量计算，分析认为影响液滴蒸发常数的两个主要因素是环境温度和环境压力，且后者占主导地位。

关键词: RP-3航空煤油；超临界蒸发；蒸发常数；环境参数

Abstract: For current investigations related with aero-engines，there are few researches available on the supercritical evaporation of liquid hydrocarbon fuel. With the increasing requirements of high performance for aero-engines being considered，evaporation of the RP-3 aviation kerosene droplets under sub- and super-critical environment was experimentally investigated. Firstly，the variations of the square of non-dimensional diameters were explored in detail under different ambient temperature and pressure with time during the evaporation process. Comparisons of typical sub- and super-critical evaporation conditions were also made and analyzed with the purpose of studying distinction between two different evaporation conditions. Then，the curve of droplet evaporation lifetime varied with environmental parameters was plotted according to the experimental results. It is found that the influence of environmental pressure on droplet evaporation lifetime is completely distrinct in the various temperature ranges and the unsteadiness in the evaporation process gets greater with the increasing of ambient pressure and temperature simultaneously. Finally，quantitative calculation of droplet evaporation constant under different conditions were accomplished. The results show that ambient temperature and pressure are the two major factors which have a significant impact on droplet evaporation constant，and the ambient temperature plays an important role.

Key words: RP-3 aviation kerosene；Supercritical evaporation；Evaporation constant；Environmental parameters

周舟,范玮,靳乐,张晋,申帅. 单个RP-3航空煤油液滴的超临界蒸发实验研究[J]. 推进技术, 2016, 37(8): 1422-1430.

ZHOU Zhou,FAN Wei,JIN Le,ZHANG Jin,SHEN Shuai. Experimental Investigation on Supercritical Evaporation of[J]. Journal of Propulsion Technology, 2016, 37(8): 1422-1430.

参考文献

[1] Litchford R,Parigger C, Jeng S. Supercritical Droplet Gasification Experiments with Forced Convection[R]. AIAA 92-3118.
[2] Givler S, Abraham J. Supercritical Droplet Vaporization and Combustion Studies[J]. Progress in Energy and Combustion Science, 1996, 22(1): 1-28.
[3] DENG Hong-wu, ZHU Kun, XU Guo-qiang, et al. Heat Transfer Characteristics of RP-3 Kerosene at Supercritical Pressure in a Vertical Circular Tube[J]. Journal of Enhanced Heat Transfer, 2012, 19(5): 409-421.
[4] 李中洲, 朱惠人. 超临界压力下航空煤油传热特性[J]. 推进技术, 2011, 32(2): 261-265. (LI Zhong-zhou, ZHU Hui-ren. Heat Transfer Characteristics of Kerosene in Micro-channel under Supercritical Pressure[J]. Journal of Propulsion Technology, 2011, 32(2):261-265.)
[5] 王英杰, 徐国强, 邓宏武, 等. 超临界RP-3管内换热特性实验[J]. 推进技术, 2009, 30(6): 656-660. (WANG Ying-jie, XU Guo-qiang, DENG Hong-wu, et al. Experimental Investigation on Heat Transfer of Supercritical RP-3[J]. Journal of Propulsion Technology, 2009, 30(6): 656-660.)
[6] Rosner D, Chang W. Transient Evaporation and Combustion of a Fuel Droplet near Its Critical-Temperature[J]. Combustion Science and Technology, 1973, 7(4):145-158.
[7] Yang V, Lin N. Vaporization of Liquid-Oxygen(LOx) Droplets in Supercritical Hydrogen Environments[J]. Combustion Science and Technology, 1994, 97(4-6): 247-270.
[8] Nomura H, Ujiie Y, Rath H J, et al. Experimental Study on High Pressure Droplet Evaporation Using Microgravity Conditions[J]. Proceedings of the Combustion Institute, 1996, 26(1): 1267-1273.
[9] Hartfield J, Farrell P. Droplet Vaporization in a High-pressure Gas[J]. Journal of Heat Transfer-Transactions of the ASME, 1993, 115(3): 699-706.
[10] Stengele J, Prommersberger K, Willmann M, et al. Experimental and Theoretical Study of One- and Two-Component Droplet Vaporization in a High Pressure Environment[J]. International Journal of Heat and Mass Transfer, 1999, 42(14): 2683-2694.
[11] Oefelein J C. LES of Supercritical LOx-H2 Injection and Combustion in a Shear-Coaxial Uni-Element Rocket[R]. AIAA 2003-479.
[12] Lacaze G, Oefelein J C. A Non-Premixed Combustion Model Based on Flame Structure Analysis at Supercritical Pressures[J]. Combustion and Flame, 2012, 159(6): 2013-2087.
[13] Wood C, Mcdonnell V, Smith R, et al. Development and Application of a Surrogate Distillate Fuel[J]. Journal of Propulsion and Power, 1989, 5(4): 399-405.
[14] Edwards T, Maurice L. Surrogate Mixtures to Represent Complex Aviation and Rocket Fuels[J]. Journal of Propulsion and Power, 2001, 17(2): 461-466.
[15] Dagaut P. On the Kinetics of Hydrocarbons Oxidation from Natural Gas to Kerosene and Diesel Fuel[J]. Physical Chemistry Chemical Physics, 2002, 11(4): 2079-2094.
[16] 范学军, 俞刚. 大庆RP-3航空煤油热物性分析[J]. 推进技术, 2006, 27(2): 187-192. (FAN Xue-jun, YU Gang. Analysis of Thermal Physical Properties of Daqing RP-3 Aviation Kerosene[J]. Journal of Propulsion Technology, 2006, 27(2): 187-192.)
[17] DENG Hong-wu, ZHANG Chun-ben, XU Guo-qiang, et al. Visualization Experiments of a Specific Fuel Flow Through Quartz-Glass Tubes under both Sub-and Supercritical Conditions[J]. Chinese Journal of Aeronautics, 2012, 25(3): 372-380.
[18] Yang J-R, Wong S-C. An Experimental and Theoretical Study of the Effects of Heat Conduction through the Support Fiber on the Evaporation of a Droplet in a Weakly Convective Flow[J]. International Journal of Heat Mass Transfer, 2002, 45(23): 4589-4598.
[19] ZHANG Hong-tao. Evaporation of a Spherical Moving Fuel Droplet over a Wide Range of Ambient Pressures within a Nitrogen Environment[D]. Nebraska: University of Nebraska-Lincoln, 2000.
[20] Jia H, Gogos G. High Pressure Droplet Vaporization; Effects of Liquid-Phase Gas Solubility[J]. International Journal of Heat and Mass Transfer, 1993, 36(18): 4419-4431.
[21] Ristau R, Nagel U, Iglseder H, et al. Theoretical and Experimental Investigations on Droplet Evaporation and Droplet Ignition at High Pressures[J]. Microgravity Science and Technology, 1993, 6(4): 223-228.(编辑:梅瑛)　　　　　　　　　　　　　*　收稿日期:2015-02-18；修订日期:2015-04-20。基金项目:国家自然科学基金(91441201；51176158；51376151)；教育部博士点基金(20126102110029)。作者简介:周舟,男,硕士生,研究领域为发动机燃烧与流动。E-mail: zhouzhou201118@163.com