尾迹对涡轮叶栅边界层转捩的影响

推进技术 ›› 2017, Vol. 38 ›› Issue (3): 532-538.

尾迹对涡轮叶栅边界层转捩的影响

李虹杨^1,2,郑赟^1,2

北京航空航天大学能源与动力工程学院，北京 100191; 先进航空发动机协同创新中心，北京 100191,北京航空航天大学能源与动力工程学院，北京 100191; 先进航空发动机协同创新中心，北京 100191

发布日期:2021-08-15
作者简介:李虹杨，男，博士生，研究领域为非定常流动及换热的数值模拟，流、热耦合数值模拟。

Effects of Wake on Boundary Layer Transition of Turbine Cascade

School of Energy and Power Engineering，Beihang University，Beijing 100191，China; Collaborative Innovation Center of Advanced Aero-Engine，Beijing 100191，China and School of Energy and Power Engineering，Beihang University，Beijing 100191，China; Collaborative Innovation Center of Advanced Aero-Engine，Beijing 100191，China

Published:2021-08-15

摘要/Abstract

摘要： 为研究周期性尾迹对下游涡轮叶栅边界层转捩的影响机理，并验证[γ-Reθ]转捩模型在非定常计算中的适用性，在自行开发的CFD程序上实现了该模型，对带有尾迹发生器的T106D-EIZ涡轮叶栅进行数值模拟；对比分析了实验数据与数值模拟的结果，并对流动机理进行阐述。主要结论如下:[γ-Reθ]转捩模型对周期性尾迹影响下的边界层转捩预测得较为准确，转捩位置随时间的变化规律及幅值均与实验值符合得很好；尾迹的时均作用是使吸力面转捩位置向尾缘移动，相比于无尾迹情况其移动距离约为5%轴向弦长；尾迹使吸力面阻力系数时均值较无尾迹情况增加约40%，同时减弱了分离泡的强度，但对分离泡的位置影响不大。

Abstract: For the instance of researching the mechanism of the effects of periodic wakes on boundary layer transition of downstream turbine blade，and verifying the applicability of[γ-Reθ]transition model in the unsteady simulation，an internal CFD code was used to implement this model to make a numerical simulation of T106D-EIZ turbine cascade，which was with wake generators. Comparative analyses for numerical results and experimental data were made and some related flow mechanism was described，getting main conclusions as follows: [γ-Reθ]performs well in predicting the effects of periodic wakes on boundary layer transition，changes of transition location with time and the moving amplitude are both in good agreement with the experimental values. Time averaged effect of the wake tends to shift the transition position down-stream，for the length about 5% axial chord compared with the no-wake condition. Existence of the wakes increase time averaged friction coefficient for about 40%，and weaken the strength of separation bubble at the same time，while，little influence is made on the position of separation bubble.

Key words: Transition；Wake；Boundary layer；Turbine cascade；Intermittency factor；Unsteady

李虹杨,郑赟. 尾迹对涡轮叶栅边界层转捩的影响[J]. 推进技术, 2017, 38(3): 532-538.

LI Hong-yang^1,2,ZHENG Yun^1,2. Effects of Wake on Boundary Layer Transition of Turbine Cascade[J]. Journal of Propulsion Technology, 2017, 38(3): 532-538.

参考文献

[1] Howard P Hodson, Robert J Howell. The Role of Transition in High-Lift Low-Pressure Turbines for Aeroengines[J]. Progress in Aerospace Sciences, 2005, 41(6): 419-454.
[2] Mayle R E. The Role of Laminar-Turbulent Transition in Gas Turbine Engines[J]. Journal of Turbomachinery, 1997, 113: 509-537.
[3] Sarkar S, Voke P R. Large-Eddy Simulation of Unsteady Surface Pressure over a Low-Pressure Turbine Blade due to Interactions of Passing Wakes and Inflexional Boundary Layer[J]. Journal of Turbomachinery, 2006, 128(2): 221-231.
[4] Gier J, Franke M, Hu?Bner N, et al. Designing Low Pressure Turbines for Optimized Airfoil Lift[J]. Journal of Turbomachinery, 2010, 132(3).
[5] Hodson H P, Howell R J. Bladerow Interactions, Transition, and High-Lift Aerofoils in Low-Pressure Turbines[J]. Annual Review of Fluid Mechanics, 2005, 37:71-98.
[6] Hodson H, Dawes W. On the Interpretation of Measured Profile Losses in Unsteady Wake-Turbine Blade Interaction Studies[R]. ASME 96-GT-494.
[7] Zarzycki R, Elsner W, Zarzycki R. The Effect of Wake Parameters on the Transitional Boundary Layer on Turbine Blade[J]. Proceedings of the Institution of Mechanical Engineers Part a Journal of Power & Energy, 2005, 219: 471-480.
[8] Piotrowski W, Lodefier K, Kubacki S, et al. Comparison of Two Unsteady Intermittency Models for Bypass Transition Prediction on a Turbine Blade Profile[J]. Flow Turbulence & Combustion, 2008, 81(3): 369-394.
[9] Stadtmüller P, Fottner L. A Test Case for the Numerical Investigation of Wake Passing Effects on a Highly Loaded LP Turbine Cascade Blade[J]. American Society of Mechanical Engineers, 2001, 1(3).
[10] Cardamone P, Stadtmu?Ller P, Fottner L. Numerical Investigation of the Wake-Boundary Layer Interaction on a Highly Loaded LP Turbine Cascade Blade[R]. ASME 2002-GT-30367.
[11] Pecnik R, Sanz W, Pieringer P. Numerical Investigation of Unsteady Boundary Layer Transition Induced by Periodically Passing Wakes with an Intermittency Transport Equation[R]. ASME 2004-GT-53204.
[12] Lodefier K, Dick E. RANS Modelling of Wake Induced Transition with the Dynamic Intermittency Concept[R]. ASME 2006-GT-90044.
[13] 乔渭阳, 赵磊, 罗华玲, 等. 低雷诺数涡轮叶片边界层转捩及分离特性测量[J]. 推进技术, 2012, 33(6): 859-865. (QIAO Wei-yang, ZHAO Lei, LUO Hua-ling, et al. Measurement of the Transition and Separation for Turbine Blade Boundary Layer with Low-reynolds Number[J]. Journal of Propulsion Technology, 2012, 33(6): 859-865.)
[14] 李伟, 朱俊强, 李钢, 等. 基于表面热膜的超高负荷低压涡轮叶栅附面层特性[J]. 航空动力学报, 2011, 26(1): 115-121.
[15] 叶建, 邹正平. 低雷诺数下周期性尾迹/层流分离泡相互作用的大涡模拟[J]. 工程热物理学报, 2007, 28(2): 215-218.
[16] 张伟昊, 刘火星, 李维, 等. 尾迹与涡轮叶栅边界层的相互作用[J]. 航空动力学报, 2009, 24(4): 843-850.
[17] 刘志刚, 叶建, 邹正平. 有/无尾迹作用下低压涡轮叶栅分离边界层转捩的大涡模拟[J]. 航空动力学报, 2013, 28(12): 2803-2812.
[18] Smith AMO, Gamberoni N. Transition, Pressure Gradient and Stability Theory[R]. California: Report ES 26388, Douglas Aircraft Co.EI Segundo, 1956.
[19] 张玉伦, 王光学, 孟德虹, 等. [γ-Reθ]转捩模型的标定研究[J]. 空气动力学学报, 2011, 29(3): 295-301.
[20] Menter F R, Langtry R B, Likki S R, et. al. A Correlation Based Transition Model Using Local Variables: Part I-Model Formulation[R]. ASME 2004-GT-53452.
[21] Misaka T. Application of Local Correlation- Based Transition Model to Flows Around Wings[R]. AIAA 2006-918.
[22] Yoshiara T, Sasaki D, Nakahashi K. Conjugate Heat Transfer Simulation of Cooled Turbine Blades Using Unstructured-Mesh CFD Solver [R]. AIAA 2011-498.
[23] Khayatzadeh P, Nadarajah S. Laminar-Turbulent Flow Simulation for Wind Turbine Profiles Using the[γ-Reθ]Transition Model[J]. Journal of Wind Energy, 2014, 17(6): 901-918.
[24] 郑赟, 李虹杨, 刘大响. [γ-Reθ]转捩模型在高超声速下的应用及分析[J]. 推进技术, 2014, 35(3): 296-304. (ZHENG Yun, LI Hong-yang, LIU Da-xiang. Application and Analysis of [γ-Reθ]Transition Model in Hypersonic Flow[J]. Journal of Propulsion Technology, 2014, 35(3): 296-304.)
[25] 郑赟, 李虹杨. 基于新的经验关联公式的[γ-Reθ]转捩模型在高超声速流动中的应用[J]. 推进技术, 2015, 36(6): 839-845. (ZHENG Yun, LI Hong-yang, Application of[γ-Reθ]Transition Model in Hypersonic Flow Based on New Correlation Equation[J]. Journal of Propulsion Technology, 2015, 36(6): 839-845.)
[26] ZHANG Xiaodong, GAO Zhenghong. A Numecal Research on a Compressibility-Correlated Langtry’s Transition Model for Double Wedge Boundary Layer Flows [J]. Chinese Journal of Aeronautics, 2011, 24(3): 249-257.
[27] Menter F R, Langtry R, V?lker S. Transition Modelling for General Purpose CFD Codes[J]. Flow Turbulence and Combustion, 2006, 77(1-4): 277-303.
[28] Langtry R B. A Correlation-Based Transition Model Using Local Variables for Unstructured Parallelized CFD Codes.[D]. Stuttgart: University of Stuttgart, 2006.
[29] 郑赟. 基于非结构网格的气动弹性数值方法研究[J]. 航空动力学报, 2009, 24(9): 2069-2077.
[30] 肖大启, 郑赟, 杨慧. 轴向间距对转子叶片气动激励的影响[J]. 航空动力学报, 2012, 27(10): 2307-2313.